Earth Rangers Centre | Woodbridge, ON

Combined Heating and Cooling
The Earth Rangers Centre is one of the first buildings of its kind in North America. “This technology offers a number of advantages over traditional forced air systems,” said Mark Euteneier, president of Klimatrol Environmental Systems. “A radiant system benefits the environment by using less fuel, plus it is less costly to maintain. The REHAU system benefits the Earth Rangers project in particular, as it eliminates ductwork in which animals can hide, and it utilizes a concrete floor surface that’s easy to clean and maintain.”

The REHAU system also complements the building’s energy-conserving structure–reinforced concrete with load-bearing masonry walls in the animal areas. The interior concrete walls and masonry are able to function as thermal storage, improving the comfort and energy performance of the building.

For the radiant heating and cooling system, 74,000 ft (22,555 m) of REHAU’s RAUPEX 0₂ barrier pipe–34,000 ft of 5/8 in. and 40,000 ft of 1/2 in.–was installed in more than 36,000 ft²(3345 m²)of exposed concrete slabs at 6 and 12 in. spacing. Tubing was suspended midway in the 8 to 12 in. thick slabs using chairs and 6 x 6 in. wire mesh between two layers of reinforcing steel. This placing provided an approximate 3 in. clearance for future fasteners to be drilled in below for pipe and duct hangers. Since slabs with radiant tubing cannot be core-drilled, significant coordination was required for the installation of the electrical conduit and mechanical slab penetrations.

RAUPEX was installed in both the floor and ceiling–as well as in the cast-in-place skylights–in order to collect, distribute and maximize solar gain. A high efficiency Viessmann Vertomat 1 mBtu output hot water boiler was specified as the heat source.

The combined ceiling and floor slab mounting design would enable the system to provide both efficient heating and cooling. The system’s cooling function employs concrete slabs that are actively cooled to approximately 64º F (17.8º C) overnight using circulating water from a cooling tower or geothermal wells. The slabs warm up slightly during the day as they absorb heat from the space. This technique provides much of the building’s cooling energy on an average day and significantly cuts electricity use. A low-energy-consuming evaporative cooling tower provides most of the energy, supplemented by a small electric chiller. In all, the cooling load for ventilation and space conditioning is only 64 tons–less than half that of a comparably-sized conventional building.

The heating function provides additional efficiency. “Typically for a low-energy building, if a slab has adequate capacity for cooling, it will have more than enough capacity for heating,” explained Richard Lay. “Fortunately, overhead heating with low-temperature heated slabs does not produce radiant asymmetry–or ‘hot head syndrome’–and is comfortable when combined with a tight, well-insulated building envelope with high-performance windows.”

Radiant ceiling heating also creates a uniformly comfortable environment for the animals, without the drafts, dust and noise sometimes associated with forced-air systems.

“So far it’s been very comfortable here,” said Phil Ruhl, facility manager for the Earth Rangers Centre. “Due to the pleasing climate, there’s also been a lot of interest in radiant heating systems from those touring the facility.”